American Honda Motor Co. (Honda) is recalling certain model year 2015 Crosstour 4 Cylinder vehicles manufactured October 1, 2014, to November 4, 2014, Crosstour V6 2WD vehicles manufactured September 30, 2014, to November 13, 2014, and Crosstour V6 4WD vehicles manufactured September 30, 2014, to November 18, 2014.
The inflator tube for the side curtain air bag may have been incorrectly manufactured.
Honda will notify owners, and dealers will replace the left and/or right side curtain air bags, free of charge. The recall begin January 30, 2015.
Owners may contact Honda customer service at 1-310-783-2000.
Honda’s number for this recall is JN0, JN1, and JN3.
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
January 10, 2015
01264-01338 Version 2
Safety Recall: Both Driver’s and Passenger’s Side Curtain Airbag May Not Inflate Properly
Supersedes 14-081, dated December 12, 2014, to revise the information highlighted in yellow.
|2015||Crosstour||ALL||Check the iN VIN status for eligibility|
There are three bulletins addressing the 2015 Crosstour side curtain airbags. Make sure you do the bulletin as directed by the iN VIN status inquiry.
S/B 14-079, Safety Recall: Driver’s (Left) Side Curtain Airbag May Not Inflate Properly
S/B 14-080, Safety Recall: Passenger’s (Right) Side Curtain Airbag May Not Inflate Properly
S/B 14-081, Safety Recall: Both Driver’s and Passenger’s Side Curtain Airbag May Not Inflate Properly
Owners of affected vehicles will be sent a notification of this campaign.
Do an iN VIN status inquiry to make sure the vehicle is shown as eligible.
Some vehicles affected by this campaign may be in your new or used vehicle inventory. These vehicles must be repaired before they are sold.
Should your dealership sell an unrepaired vehicle that subsequently causes injury or damage because of the recalled item, the dealership will be solely responsible to the damaged party, and will be required to defend and indemnify American Honda for any resulting claims. To see if a vehicle in inventory is affected by this recall, do a VIN status inquiry before selling it.
Replace both the driver’s (left) and the passenger’s (right) side curtain airbag module.
|Part Name||Part Number||Quantity|
|Driver’s (Left) Side Curtain Airbag Module||78875-TP6-A80||1|
|Passenger’s (Right) Side Curtain Airbag Module||78870-TP6-A80||1|
NOTE: Follow your standard process for disposing of the side curtain airbags.
WARRANTY CLAIM INFORMATION
|Operation Number||Description||Flat Rate||Defect Code||Symptom Code||Template ID||Failed Part Number|
|7541B3||Replace the driver’s|
(left) and passenger’s (right) side curtain airbag.
Do not disconnect the roof wire harness from the driver’s dash area; once the headliner is lowered, detach the roof wire harness from the headliner by carefully peeling back just enough tape to remove the harness.
- Do not remove all of the tape; it will be reused.
- Make sure the roof wire harness is out of the way so that it does not get tangled with the headliner when you remove it from the vehicle.
- Leave the AM/FM antenna attached to the headliner.
- Replace both the driver’s (left) and the passenger’s (right) side curtain airbag with a new part.
- Confirm the proper system operation by turning the ignition to ON (II), and check that the SRS indicator comes on for about 6 seconds, then goes off.
- Reinstall the headliner in the reverse order of removal.